John Deere 5075M, 5090M, 5100M, 5100MH, and 5115M (FT4) Nov 2020- tractors operator's manual (OMSU63224)

Table of Contents for JD-OMSU63224 manual

• Introduction
  • Foreword
  • Emissions Performance and Tampering
• General Information
  • Product View
  • Trademarks
  • Glossary of Terms
  • Regions and Country Versions
  • Machine Overview
• Safety Precautions
  • Recognize Safety Information
  • Understand Signal Words
  • Follow Safety Instructions
  • Prepare for Emergencies
  • Wear Protective Clothing
  • Protect Against Noise
  • Handle Fuel Safely-Avoid Fires
  • Handle Starting Fluid Safely
  • Fire Prevention
  • In Case of Fire
  • Avoid Static Electricity Risk When Refueling
  • Keep ROPS Installed Properly
  • Use Foldable ROPS and Seat Belt Properly
  • Stay Clear of Rotating Drivelines
  • Use Steps and Handholds Correctly
  • Read Operator's Manuals for ISOBUS Controllers
  • Use Seat Belt Properly
  • Operating the Tractor Safely
  • Avoid Backover Accidents
  • Limited Use in Forestry Operation
  • Operating the Loader Tractor Safely
  • Keep Riders Off Machine
  • Instructional Seat
  • Use Safety Lights and Devices
  • Use a Safety Chain
  • Transport Towed Equipment at Safe Speeds
  • Use Caution on Slopes, Uneven Terrain, and Rough Ground
  • Freeing a Mired Machine
  • Avoid Contact with Agricultural Chemicals
  • Handle Agricultural Chemicals Safely
  • Handling Batteries Safely
  • Avoid Heating Near Pressurized Fluid Lines
  • Remove Paint Before Welding or Heating
  • Handle Electronic Components and Brackets Safely
  • Practice Safe Maintenance
  • Avoid Hot Exhaust
  • Clean Exhaust Filter Safely
  • Work In Ventilated Area
  • Support Machine Properly
  • Prevent Machine Runaway
  • Park Machine Safely
  • Transport Tractor Safely
  • Service Cooling System Safely
  • Service Accumulator Systems Safely
  • Service Tires Safely
  • Service Front-Wheel Drive Tractor Safely
  • Tightening Wheel Retaining Bolts/Nuts
  • Avoid High-Pressure Fluids
  • Do Not Open High-Pressure Fuel System
  • Store Attachments Safely
  • Decommissioning - Proper Recycling and Disposal of Fluids and Components
• Safety Signs
  • Replace Safety Signs
  • Operators Manual (Cab)
  • Operators Manual (OOS)
  • Use Seat Belt Properly (Cab)
  • Use Seat Belt Properly (OOS)
  • Instructional Seat
  • Starter
  • PTO Shield
  • Tow Implement Properly
  • Front End Loader
  • Engine Coolant Heater
  • ROPS
• Controls and Instruments
  • Front Console Controls
  • Foot Operated Controls
  • Console Controls-Cab
  • Console Controls-Open Operator Station
  • Transmission Controls
  • Multi-Function Lever/Mid-SCV Controls
  • Rear SCV Controls
  • Rear Hitch Controls
  • Rear PTO Controls
  • Heat and Air Conditioning Controls
• Engine Operation
  • Required Machine Stop Warning
  • Engine Fuel System and Power Rating
  • Check Engine Indicators and Gauges
  • Operate Key Switch
  • Start Engine
  • Cold Weather Start
  • Run Engine
  • Engine Speeds and Operational Procedures
  • Stop Engine
  • Restart Engine That Has Run Out of Fuel
  • Engine Block Coolant Heater
• Air Intake, Fuel, Coolant, and Exhaust Operation
  • Aftertreatment Indicators Overview
  • Selective Catalytic Reduction (SCR) System Overview
  • US EPA Qualified Emergency Use - SCR Derate Override Option
  • Fuel and Diesel Exhaust Fluid (DEF) Level Gauges
  • Fill Fuel Tank
  • Fill Diesel Exhaust Fluid (DEF) Tank
  • Reduce Fuel Consumption
  • Exhaust Filter Cleaning
  • Exhaust Filter System Overview
  • Automatic (AUTO) Exhaust Filter Cleaning
  • Disabled Exhaust Filter Cleaning
  • Parked Exhaust Filter Cleaning
  • Service Exhaust Filter Cleaning
• Electrical and Lighting Operation
  • Light Switch
  • Headlights
  • Loader Lights
  • Bucket Lights
  • Tail and Brake Lights
  • Turn Signals
  • Warning Lights
  • Beacon Lights
  • Front Work Lights
  • Rear Work Lights
  • Dome Light
  • Map Light
  • Right-Hand Console Light
  • Horn
  • Backup Alarm
  • Front Wiper and Washer
  • Rear Wiper and Washer
  • Radio
  • Auxiliary Input and USB Port
  • Bluetooth® Microphone
  • Speakers
  • Radio Antenna
  • Satellite Module and Antenna
  • Implement Connector
  • Power Outlet
  • Convenience Outlets
  • Auxiliary Power Strip
  • Service ADVISOR™ Connector
  • Operator Presence
  • JDLink™
• Displays, Software, and Electronics Operation
  • Primary Display
• Drivetrain Operation
  • Drivetrain Information
  • Off Level Operation
• Transmission Operation
  • Electrohydraulic Transmission System Indicator
  • 16/16 Transmission
  • 32/16 Transmission
  • Reverser Modulation
  • Creeper Gear Operation
  • Downhill Operation in Slippery Conditions
  • 16/16 Transmission Ground Speed Chart
  • 32/16 Transmission Ground Speed Chart
  • 16/16 Creeper Ground Speed Chart
  • 32/16 Creeper Ground Speed Chart
  • Correction Factors for Other Tire Sizes
• MFWD and Front Axle Operation
  • Mechanical Front-Wheel Drive (MFWD On/Off)
  • Mechanical Front-Wheel Drive (MFWD On/Auto/Brake Assist)
• Differential and Rear Axle Operation
  • Differential Lock
• Power Take-Off (PTO) Operation
  • Match Machine Power to Implement
  • PTO Guard
  • PTO Shield
  • PTO Drive Shaft Shield
  • Select PTO Drawbar Position
  • Exchangeable 540/1000 rpm PTO Shaft
  • Attach PTO Driven Implement
  • Select Correct PTO Speed
  • Operate Rear PTO
  • Operate Rear Remote PTO
  • PTO Automatic Disengage
  • PTO Alarm
• Steering and Brake Operation
  • Service Brakes
  • AutoTrac™ Universal Information
• Hydraulics Operation
  • Warm Transmission/Hydraulic Oil
  • Open Center Hydraulics
• Hitch and Drawbar Operation
  • Match Machine Power to Implement
  • Rear Hitch Controls
  • Rear Hitch Components
  • Operate Mechanical Position Control
  • Operate Mechanical Draft Control
  • Operate Mechanical Rate-of-Drop Control
  • Electrohydraulic Hitch System Indicator
  • Operate Electrohydraulic Position Control
  • Operate Electrohydraulic Draft Control
  • Operate Electrohydraulic Rate-of-Drop Control
  • Operate Electrohydraulic Height Limit Control
  • Operate Electrohydraulic Hitch Fender Switch
  • Operate Manual Lower for Electrohydraulic Hitch
  • Prepare Implement
  • Hitch Conversion - Category II to I
  • Position Center Link
  • Adjust Lateral Float
  • Attach Implement to Rear Hitch
  • Level Hitch
  • Adjust Hitch Side Sway
  • Quick Coupler
  • Front Hitch Components
  • Front Implement Connection
  • Front Hitch and Coupler Operation
  • Drawbar Settings
  • Clevis Drawbar
  • Drawn Implement Connection
• Selective Control Valve Operation
  • Rear SCV Controls and Components
  • Mid-SCV Controls and Components
  • Front Hitch and SCV
  • Connect Hydraulic Hoses
  • Connect to Rear SCVs
  • Connect to Mid-SCVs
  • Correct Reversed Cylinder Response
  • Single-Acting Cylinders
  • Implements Requiring Large Volumes of Oil
  • Set SCV Detents
  • Operate Hydraulic Motor with Rear SCV
  • Operate Power Beyond with Rear SCV
  • Operate Loader with Rear SCV
  • Adjust Flow Control
  • Power Beyond
  • Case Drain
  • Motor Return
  • Fast Return-to-Sump
  • Rear SCV Oil Collection
• Wheels and Tires Operation
  • Wheels and Tires Information
• Ballasting
  • Ballasting Information
• Additional Equipment
  • Tool Box
  • Front Loader
  • Lockable Fuel Fill Cap
  • Hood Latch
• Operator's Station Operation
  • Doors
  • Grab Handles
  • Windows
  • Window Shades
  • Mirrors
  • Foldable ROPS
  • Cab Seats
  • OOS Seats
  • Adjust Seat Armrests
  • Instructional Seat
  • Steering Wheel
  • Heat, Defrost, and Air Conditioning
  • Storage Drawer
  • General Storage
  • Field Office™
  • Monitor Mounts
  • Rear Window Cable Routing
  • Coat Hook
  • Ash Tray and Cigarette Lighter
• Transport and Storage
  • Keep Machines Secure
  • Deliver Safely
  • Road Transportation
  • Towing Loads
  • Come Home Mode - PowrReverser Transmission
  • Tow Machine
  • Front Tow Points
  • Rear Tow Points
  • Machine Storage
  • Remove Machine from Storage
• Maintenance Intervals
  • Maintain Daily Before Start-Up
  • Maintenance Interval Chart
• Fuels, Lubricants, and Coolants
  • Alternative and Synthetic Lubricants
  • Diesel Engine Coolant (engine with wet sleeve cylinder liners)
  • Operating in Warm Temperature Climates
  • John Deere COOL-GARD™ II Coolant Extender
  • Water Quality for Mixing with Coolant Concentrate
  • Testing Coolant Freeze Point
  • Diesel Exhaust Fluid (DEF) - Use in Selective Catalytic Reduction (SCR) Equipped Engines
  • Disposal of Diesel Exhaust Fluid (DEF)
  • Refilling Diesel Exhaust Fluid (DEF) Tank
  • Storing Diesel Exhaust Fluid (DEF)
  • Testing Diesel Exhaust Fluid (DEF)
  • Diesel Engine Oil Service Interval for Operation at High Altitude
  • Diesel Engine Oil - Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
  • Engine Oil and Filter Service Intervals - Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
  • John Deere Break-In Plus™ Engine Oil - Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
  • Oil Filters
  • Fuel Filters
  • Diesel Fuel
  • Handling and Storing Diesel Fuel
  • Lubricity of Diesel Fuel
  • Testing Diesel Fuel
  • Biodiesel Fuel
  • Minimizing the Effect of Cold Weather on Diesel Engines
  • Supplemental Diesel Fuel Additives
  • Multipurpose Extreme Pressure (EP) Grease
  • Mixing of Lubricants
  • Lubricant Storage
  • Oilscan™ and CoolScan™
  • Transmission, Steering, Brake, Hydraulic, and Gear Case Oil
• As Required Maintenance
  • Maintain As Required
  • Paint and Finish Care
  • Wash Machine
• Controls and Instruments Maintenance
  • General Controls and Instruments Maintenance
• Engine Maintenance
  • Break-In Maintenance
  • Break-In Checks
  • Check Engine Oil Level
  • Change Engine Oil and Filter (4.5 Liter 4 Cylinder Engine)
  • Change Engine Oil and Filter (2.9 Liter 3 Cylinder Engine)
  • Clean Open Crankcase Vent (OCV)
  • Change Open Crankcase Vent Filter (OCV)
  • Check Fan Belt Tensioner (4.5 Liter 4 Cylinder Engine)
  • Replace Fan Belt (4.5 Liter 4 Cylinder Engine)
  • Inspect and Adjust Alternator Belt (2.9 Liter 3 Cylinder Engine)
  • Replace Alternator Belt (2.9 Liter 3 Cylinder Engine)
  • Inspect and Adjust Air Conditioning Compressor Belt (2.9 Liter 3 Cylinder Engine)
  • Replace Air Conditioner Compressor Belt (2.9 Liter 3 Cylinder Engine)
  • Adjust Engine Valve Clearance
• Air, Fuel, Coolant, and Exhaust Maintenance
  • Required Emission-Related Information
  • Recommended Dealer Performed Service
  • Check Engine and Exhaust Compartments for Debris
  • Clean Diesel Particulate Filter (DPF)
  • Change Diesel Exhaust Fluid (DEF) In-Line Filter
  • Change Diesel Exhaust Fluid (DEF) Dosing Unit Filter
  • Replace Diesel Exhaust Fluid (DEF) Tank Header Suction Screen
  • Clean Diesel Exhaust Fluid (DEF) Tank
  • Drain Diesel Exhaust Fluid (DEF) Tank
  • Service Air Cleaner Elements
  • Tighten Air Intake and Engine Cooling Hose Clamps
  • Clean Air Filter Dust Unloading Valve
  • Clean Grille Screens and Cooling Package
  • Do Not Modify Fuel System
  • Drain Water and Sediment from Fuel Filter
  • Bleed Fuel System
  • Replace Fuel Filters
  • Clean Fuel Tank Vent Filter
  • Check Coolant Level
• Electrical and Lighting Maintenance
  • Use Booster Battery or Charger
  • Battery Maintenance
  • Replace Battery
  • Replace Fusible Link
  • Replace Cab Fuses
  • Replace OOS Fuses
  • Handle Halogen Light Bulbs Safely
  • Replace Halogen Headlight Bulb
  • Replace LED Headlight
  • Headlight Adjustment
  • Replace Loader Light Bulb
  • Replace Bucket Light
  • Replace Cab Tail/Turn/Brake Light Bulb
  • Replace OOS Tail/Turn/Warning/Brake Light Bulb
  • Replace Cab Warning Light Bulb
  • Replace Canopy Warning Light Bulb
  • Replace Cab Halogen Work Light Bulb
  • Replace Cab LED Worklight
  • Replace OOS Rear Work Light Bulb
  • Replace OOS Fender Light Bulb
  • Replace Beacon Light Bulb
  • Replace Dome Light Bulb
  • Replace Map Light Bulb
  • Replace Right-Hand Console Light Bulb
• Drive Train Maintenance
  • Drivetrain Information
• Transmission Maintenance
  • Change Transmission/Hydraulic Oil and Filter
  • Check Neutral Start System
  • Check Transmission Park System
  • Adjust Park Position Bracket
  • Replace Transmission Dampener
• MFWD and Front Axle Maintenance
  • Check Axle Pivot Pin End Play
  • Lubricate 2WD Axle Pivot Point
  • Lubricate 2WD Steering Spindles and Cylinders
  • Pack 2WD Front Wheel Bearings
  • Check MFWD Axle for Oil Leaks
  • Lubricate MFWD Axle Trunnion
  • Change MFWD Axle Wheel Hub Oil
  • Change MFWD Axle Housing Oil
• Differential and Rear Axle Maintenance
  • Lubricate Rear Axle Bearings
  • Change Hi-Crop Rear Axle Oil
• Power Take-Off (PTO) Maintenance
  • Adjust PTO Speed Shift Lever
  • Lubricate Exchangeable 540/1000 rpm PTO Shaft
• Steering and Brake Maintenance
  • Check Manual Brakes
• Hydraulics Maintenance
  • Check Transmission/Hydraulic System Oil Level
  • Change Transmission/Hydraulic Filter
  • Change Transmission/Hydraulic Oil and Filter
• Hitch and Drawbar Maintenance
  • Lubricate Draft Sensing Shaft Seal
  • Lubricate Rear Hitch
  • Lubricate Front Hitch
  • Inspect Hitch and Drawbar for Excessive Wear
• Selective Control Valve Maintenance
  • Adjust Mechanical SCV Cables
  • Empty Rear SCV Oil Collection Bottle
• Wheels and Tires Maintenance
  • Inspect Tires
  • Adjust and Check Clearance
  • Check Tire Inflation Pressure
  • Tire Pressures
  • Tire Inflation Pressure Guidelines
  • Tire Sidewall Information
  • Use Correct Tire Combinations
  • Correct Tire Selection
  • Changing Tire Sizes
  • Select Front Tire Rolling Direction
  • Rear Wheel Tread Width Limitations
  • Adjust Front Axle Width-2WD Front Axle
  • Set Tread-2WD Front Axle
  • Set Tread-Two-Position MFWD Wheels
  • Set Tread-Multi-Position MFWD Wheels
  • Set Tread-Two-Position Rear Wheels
  • Set Tread-Multi-Position Rear Wheels
  • Tighten Wheel Bolts Correctly
  • Install Wheel Spacer
  • Tighten Wheel Bolts-2WD Front Axle
  • Tighten Wheel Bolts-MFWD Axle
  • Tighten Wheel Bolts-Rear Axle
  • Jacking Up Machine
  • Check Toe-In-2WD Axle
  • Adjust Toe-In-2WD Axle
  • Check Toe-In-MFWD Axle
  • Adjust Toe-In-MFWD Axle
  • Set Steering Stops
• Ballasting Maintenance
  • General Ballast Information
  • Select Ballast Carefully
  • Front-End Ballast
  • Rear Wheel Ballast
  • Control Power Hop - MFWD
  • Add Liquid Ballast to Tires
  • Remove Liquid Ballast from Tires
  • Measure Wheel Slip
• Additional Equipment Maintenance
  • Front Loader Bracket Installation
  • Set Pivoting Fender Brackets
  • Set Fender Position
• Operator's Station Maintenance
  • Clean Cab Air Filters
  • Check Air Conditioning System
  • Replace Wiper Blade
  • Inspect Seat Belts
  • Adjust Rear Fender-Open Operator Station
  • Keep ROPS Installed Properly
  • Keep Cab Protection System Installed Properly
• Troubleshooting
  • Engine
  • Heat and Air Conditioning
  • Electrical
  • Display
  • Transmission
  • Brakes
  • Hydraulics
  • Hitch
  • Selective Control Valves (SCV)
• On-Board Diagnostics
  • STOP, Service, Information Alert Indicators, and Alarms
  • On-Board Diagnostic Tool
• Specifications
  • Metric Bolt and Screw Torque Values
  • Unified Inch Bolt and Screw Torque Values
  • Fluid Capacities
  • Machine Dimensions
  • Machine Weight
  • Engine and PTO Power
  • Engine Specifications
  • Electrical Specifications
  • PTO Engine Speeds
  • Hydraulic Specifications
  • Rear Hitch Lift Capacities
  • Front Hitch Lift Capacities
  • Drawbar Capacities
  • Weight Distribution
  • Permissible Load
  • Ballast Capacities
  • Sound Level
• Identification Numbers
  • Record Product Identification Number
  • Record Front Axle Serial Number
  • Record Engine Serial Number (4.5 Liter 4 Cylinder Engine)
  • Record Engine Serial Number (2.9 Liter 3 Cylinder Engine)
  • Record Transmission Serial Number
  • Record Cab Serial Number
  • Record ROPS Serial Number
  • Keep Proof of Ownership
• Certification and Warranty
  • Cab ROPS Certificate
  • OOS ROPS Certificate
  • Limited Battery Warranty
  • Emissions Control System Certification Label
  • Carbon Dioxide Emissions (CO₂)
  • CARB Non-road Emissions Control Warranty Statement-Compression Ignition
  • EPA Non-road Emissions Control Warranty Statement-Compression Ignition
• Maintenance Records
  • Daily or 10 Hours
  • Weekly or 50 Hours
  • First 100 Hours
  • Every 250 Hours
  • Every 300 Hours
  • Every 500 Hours
  • Every 600 Hours
  • Every 1200 Hours
  • Annual Maintenance
  • Every 3000 Hours
  • Every 4500 Hours
  • Change of Ownership
  • Change of Ownership
  • Change of Ownership
• Index
• John Deere Service
  • Technical Information
  • John Deere Is At Your Service