John Deere 2025R compact tractor operator's manual (OMTR117482)

Table of Contents for JD-OMTR117482 manual

• Introduction
  • Foreword
• General Information
  • Product View
  • Trademarks
  • Glossary of Terms
  • Regions and Country Versions
  • Machine Overview
• Safety
  • Recognize Safety Information
  • Understand Signal Words
  • Follow Safety Instructions
  • Prepare for Emergencies
  • Wear Protective Clothing
  • Protect Against Noise
  • Handle Fuel Safely-Avoid Fires
  • Handle Starting Fluid Safely
  • Fire Prevention
  • In Case of Fire
  • Avoid Static Electricity Risk When Refueling
  • Keep ROPS Installed Properly
  • Use Foldable ROPS and Seat Belt Properly
  • Stay Clear of Rotating Drivelines
  • Use Steps and Handholds Correctly
  • Read Operator's Manuals for ISOBUS Controllers
  • Use Seat Belt Properly
  • Operating the Tractor Safely
  • Avoid Backover Accidents
  • Limited Use in Forestry Operation
  • Operating the Loader Tractor Safely
  • Keep Riders Off Machine
  • Instructional Seat
  • Use Safety Lights and Devices
  • Use a Safety Chain
  • Transport Towed Equipment at Safe Speeds
  • Use Caution on Slopes, Uneven Terrain, and Rough Ground
  • Freeing a Mired Machine
  • Avoid Contact with Agricultural Chemicals
  • Handle Agricultural Chemicals Safely
  • Handling Batteries Safely
  • Avoid Heating Near Pressurized Fluid Lines
  • Remove Paint Before Welding or Heating
  • Handle Electronic Components and Brackets Safely
  • Practice Safe Maintenance
  • Avoid Hot Exhaust
  • Clean Exhaust Filter Safely
  • Work In Ventilated Area
  • Support Machine Properly
  • Prevent Machine Runaway
  • Park Machine Safely
  • Transport Tractor Safely
  • Service Cooling System Safely
  • Service Accumulator Systems Safely
  • Service Tires Safely
  • Service Front-Wheel Drive Tractor Safely
  • Tightening Wheel Retaining Bolts/Nuts
  • Avoid High-Pressure Fluids
  • Do Not Open High-Pressure Fuel System
  • Store Attachments Safely
  • Decommissioning - Proper Recycling and Disposal of Fluids and Components
• Safety Signs
  • Replace Safety Signs
  • Use Seat Belt Properly - OOS
  • Use Seat Belt Properly - Cab
  • Operator's Manual
  • Folding ROPS
  • Canopy or Sunshade
  • Rotating Blades
  • PTO Shield
  • Starter
• Controls and Instruments
  • Front Console Controls
  • Foot-Operated Controls
  • Right-Hand Console Controls
  • Left-Hand Console Controls
  • Differential, MFWD, Rate-of-Drop, and Seat Controls
  • Cab Controls (If Equipped)
  • Instrument Control Panel
• Engine Operation
  • Operate Key Switch
  • Operate Hand Throttle
  • Operate Auto-Throttle (If Equipped)
  • Operate Fuel Shutoff Valve
  • Start the Engine
  • Cold Weather Starting Aids
  • Warm and Idle the Engine
  • To Start a Stalled Engine
  • Stop Engine
• Air Intake, Fuel, Coolant, and Exhaust Operation
  • Fill the Fuel Tank
  • Use Fuel Gauge
• Electrical and Lighting Operation
  • Use Light Switch
  • Use Turn Signal Switch
  • Use Power Port Outlet
  • Work Light (If Equipped)
  • Beacon Light (If Equipped)
• Drivetrain Operation
  • Drive Machine
• Transmission Operation
  • Operate the Hydrostatic Transmission
  • Use Cruise Control
• MFWD and Front Axle Operation
  • Use Mechanical Front Wheel Drive (MFWD)
• Differential and Rear Axle Operation
  • Use Differential Lock (Traction Assist)
• Power Take Off (PTO) Operation
  • Stay Clear of Rotating Drivelines
  • Use the PTO Safely
  • Check PTO Driveshaft Length
  • Operate Rear and Mid PTO (Operator on Seat)
  • Operate Rear PTO (Operator off Seat)
  • Operate Reverse Implement Option (RIO)
  • Adjust Height-of-Cut (If Equipped)
• Steering and Brake Operation
  • Operate Brake Pedal
  • Operate Park Brake
  • Adjust Tilt Steering Wheel
• Hydraulics Operation
  • Warm Hydraulic System Oil
  • Hydraulics Information
• Hitch and Drawbar Operation
  • Operate Attachments
  • Operate 3-Point Hitch
  • Operate Rate-of-Drop
  • Use Draft Link and Center Link
  • Level Implement Front-to-Rear
  • Level Implement Side-to-Side
  • Adjust Implement Side-to-Side Sway
  • Operate Rear Hitch
  • Operate Optional iMatch Quick-Attach Hitch System
  • Use Front Quick Hitch
  • Front Quick Hitch Compatibility
• Selective Control Valve Operation
  • Avoid High-Pressure Fluids
  • Connect Implement Hydraulic Hoses
  • Operate Hydraulic Dual Selective Control Valve (SCV)
  • Operate Selective Control Valve (SCV) Lock Lever
  • Operate Third Selective Control Valve (SCV)
  • Operate Selective Control Valve (SCV) Continuous Flow Switch
  • Operate Third Function Selective Control Valve (If Equipped)
• Wheels and Tires Operation
  • Tire Labeling, Ascertain the Load Capacity of Tires
  • Select Tire Inflation Pressure
  • Tire Combinations
  • Front and Rear Tire Capacity
• Ballast
  • Ballast Machine
  • Implement Codes
  • Use Optional Rear Cast Iron Wheel Weights
  • Use Optional Rear Ballast Box
  • Use Liquid Weight in Tires
  • Use Optional Front Weights
• Additional Equipment Operation
  • Additional Equipment Operation
• Operator Station Operation
  • Enter and Exit Machine
  • Adjust Seat
  • Use Seat Belt
  • Raise and Lower ROPS
  • Doors
  • Windows
  • Cab Heater Control
  • Front Windshield Wiper
  • Rear Windshield Wiper (If Equipped)
• Transport and Storage
  • Transport Machine on Trailer
  • Transport Machine
  • Push or Tow Machine
  • Tow Loads
  • Use Safety Chain
  • Store Safety
  • Prepare Machine for Storage
  • Prepare Fuel and Engine for Storage
  • Remove Machine from Storage
• Maintenance Intervals
  • Service Your Machine
  • Maintenance Interval Chart-Daily to Every 400 Hours
  • Maintenance Interval Chart-Every 600 Hours to Every 6000 Hours
  • Test the Safety Interlock System Before Startup
  • Avoid Damage to Plastic and Painted Surfaces
  • Clean Plastic Surfaces
  • Clean and Repair Metal Surfaces
• Fuel, Lubricants, and Coolant
  • Diesel Fuel
  • Handling and Storing Diesel Fuel
  • Testing Diesel Fuel
  • Minimizing the Effect of Cold Weather on Diesel Engines
  • Alternative and Synthetic Lubricants
  • Engine Oil
  • Diesel Engine Coolant
  • Operating in Warm Temperature Climates
  • Additional Information About Diesel Engine Coolants and John Deere COOL-GARD™ II Coolant Extender
  • Testing Diesel Engine Coolant
  • Transmission and Hydraulic Oil
  • Front Axle and MFWD Oil
  • Grease
• Maintenance-As Required
  • Service-As Required
• Controls and Instruments Maintenance
  • Controls and Instruments Maintenance
• Engine Maintenance
  • Daily Startup Procedure
  • Required Emission-Related Information
  • Avoid Fumes
  • Check Engine Oil Level
  • Change Engine Oil and Filter
  • Clean Dust Unloading Valve
  • Service the Alternator Belt
  • Clean Front and Side Grille Screens
  • Clean Engine Compartment
• Air, Fuel, Coolant and Exhaust Maintenance
  • Service Air Filter Elements (S.N. J103921-)
  • Check Air Restriction Indicator
  • Service Cab Air Filter
  • Check Air Filter Hose
  • Check and Drain Water Separator
  • Replace Fuel Filter
  • Fuel Injection Pump
  • Fuel Injection Nozzles
  • Drain and Flush Fuel Tank
  • Check Coolant Level
  • Drain and Flush Cooling System
  • Fill Cooling System
  • Check Radiator Hoses and Clamps
  • Clean Radiator, Fuel, and Transmission Cooling Fins
• Electrical and Lighting Maintenance
  • Service Electrical
  • Service the Battery Safely
  • Remove and Install Battery
  • Clean Battery and Terminals
  • Use Booster Battery
  • Replace Headlight Bulb
  • Replace Tail/Turn Light Bulb
  • Replace Warning Light Bulb
  • Replace Fuses and Relays
• Drivetrain Maintenance
  • Drivetrain Maintenance
• Transmission Maintenance
  • Check Transmission Oil Level
  • Change Transmission Oil and Filter
  • Remove and Install Oil Suction Screen
• MFWD and Front Axle Maintenance
  • Check Front Axle Oil Level
  • Change Front Axle Oil
  • Lubricate MFWD Driveshaft
  • Lubricate Main Driveline
• Differential and Rear Axle Maintenance
  • Rear Axle
• Power Take Off (PTO) Maintenance
  • PTO Maintenance
• Steering and Brake Maintenance
  • Steering Maintenance
  • Brake Maintenance
• Hydraulics Maintenance
  • Hydraulic Maintenance
• Hitch and Drawbar Maintenance
  • Lubricate 3-Point Hitch
• Selective Control Valve Maintenance
  • Check Selective Control Valve
• Wheels and Tires Maintenance
  • Check Wheel Bolts and Hardware
  • Remove and Install Wheels
  • Check Tire Pressure
  • Tire Inflation Pressure Chart
  • Select Front Tire Rolling Direction
  • Lift Points for Jacking up the Tractor
• Ballast Maintenance
  • Match Ballast to Work Load
• Additional Equipment Maintenance
  • Additional Equipment Maintenance
• Operator Station Maintenance
  • Raise and Lower Hood
  • Remove and Install Side Panels
  • Inspect ROPS for Loose Hardware
• Troubleshooting
  • Engine
  • Electrical System
  • Machine
  • Brakes
  • Steering
• On-Board Diagnostics
  • Service Alert and Information Display
• Specifications
  • Engine Specifications
  • Drivetrain Specifications
  • Hydraulic System Specifications
  • Electrical System Specifications
  • Fluid Capacities
  • Ground Speeds
  • Dimensions
  • Height from Ground
  • Ground Clearance
  • Turning Radius
  • Machine Weight
  • 3-Point Hitch Specification
  • Coupling Devices
  • How to Calculate Maximum Permissible Download on Trailer Hitch
  • How to Calculate Permissible Mass
  • Unified Inch Bolt and Screw Torque Values
  • Metric Bolt and Screw Torque Values
• Identification Numbers
  • Product Identification Information
  • Record Identification Numbers
• Certification and Warranty
  • Product Warranty
  • John Deere, California and U.S. EPA Emission Control System Warranty (Non-Road Diesel)
  • Tire Warranty
  • Limited Battery Warranty
• Service Records
  • Every 10 Hour or Daily Service
  • Every 50 Hour Service
  • Every 200 Hour Service
  • Every 400 Hour Service
  • Every 600 Hour Service
  • Yearly Service
  • Every 1000 Hour Service
  • Every 2000 Hour Service or Every Two Years
  • Every 6000 Hour Service or Every Six Years
  • Service as Required
  • Change of Ownership
  • Change of Ownership
  • Change of Ownership
• Index
• John Deere Service
  • John Deere Is At Your Service
  • Technical Information